That’s $53 billion, with a “b”
HARDLY A DAY GOES BY THAT A NEWS STORY ON FISCAL
deficits or monetary bailouts doesn’t throw around numbers that
start with a “t,” as in trillion. It’s gotten so that talk of mere billions
doesn’t rouse much interest anymore.
But there’s a number that anyone who ships, brokers, or transports
goods for a living should sit up and take notice of: $53 billion.
That’s how much Werner Enterprises, the Omaha-based truckload
giant, estimates it will cost the truckload industry to “refresh” its fleet,
reducing the average vehicle age from 6. 7 to 5. 5 years (which hardly
puts it in the “spring chicken” category) over the next 24 months.
The number came from Werner’s internal
research, and lest one thinks it represents the work
of some off-the-wall data cruncher, that figure—
and the analysis behind it—has been vetted by multiple Wall Street houses, who’ve come to pretty
much the same conclusion.
The root causes are plentiful and easy to identify.
Of course, much has been made of the escalating
cost of labor, fuel, and insurance. The cost of tires—
and we’re not talking the garden-variety Michelins
you slap on your Camry—has risen an astonishing
70 percent just in the past 18 months, according to
Werner. Then there have been the three separate
mandates from the federal government—in 2002,
2007, and 2010—requiring engine manufacturers
to upgrade their products to meet tougher emissions standards. A
fourth directive is coming down the pike in 2014. The cost of compliance with the emissions rules alone equates to a 25-percent surcharge on the industry’s rig bill, said Derek Leathers, Werner’s president and COO.
The truckload industry works on a truck-trailer ratio of 1: 3, meaning that for every tractor a carrier owns, it also has three trailers. The
cost of replacing one rig, and the trailers that go with it, has reached
$200,000, according to Werner data. Small wonder no fleet is adding
capacity; it’s tough enough just to replace what you have.
Meanwhile, prevailing freight rates are inadequate to allow many
fleets to replace their equipment. Shippers are sensitive to this, but
only on a macro level. They have their own cost pressures, and they
continue to push back against the carriers.
“Shippers are holding the line on rate increases,” said Lana R. Batts,
a long-time trucking executive and now a partner at the consultancy
Transport Capital Partners LLC.
Capacity has shrunk by 18 percent since the
freight recession hit in 2006. And there’s nothing
to indicate the situation will ease anytime soon.
Heavily in debt, facing sharply higher costs, and
operating in a tightfisted economic climate,
many carriers may simply throw in the towel,
leading to a capacity washout that will make the
last six years seem tame by comparison.
The good news is that the industry has proved
to be remarkably resilient. There will always be
new ideas to keep rigs rolling.
For example, truckload giant
Schneider National Inc. has
come up with a plan to make
truck ownership more affordable for smaller operators. In
late June, Schneider announced
it had struck a deal with
Commercial Fleet Financing
Inc. that will let a qualified
buyer get into a used Schneider
rig with no money down and
$99 a month for the first two
months.
Even Batts, who has been
around long enough to separate the wheat from
the chaff, was impressed. “It shows how creative
carriers like Schneider need to become to attract
drivers and provide capacity,” she added.
For years, this magazine has been writing
about the weakened state of the truckload industry. The Werner number—$53 billion with a
“b”—puts the problem in hard, stark terms. The
industry has fallen, and it will have a hell of a
hard time getting up. People need to pay attention. Trucking is too important for this to be
ignored.
